Standard & Triumph Service Bulletins – HUGE ARCHIVE
November 1st, 2007 | 
Author: 1954 Triumph Bulletins
Eight/2/M Suppression of Radio and Television Interference January 1954
Eight/4/N Approved Adhesives for Service Work January 1954
Sports/2/A Service Information Binders January 1954
Sports/3/A Nut Tightening Torques July 1954
Sports/1/B Failure of R.P.M. Indicator Instrument or Inner Drive Cable April 1954
Sports/2/B Excessive Loss of Oil from The Crankcase Breather Pipe April 1954
Sports/3/B Reinforced Camshaft June 1954
Sports/4/B Engine Ventilation – Series II Design August 1954
Sports/5/B Engine Dimensions November 1954
Sports/6/B Modified Pistons December 1954
Sports/1/C Radiator Block and Thermostat Housing June 1954
Sports/2/C Radiator Thermostat October 1954
Sports/1/D Clutch Operating Shaft, Part No. 108887 June 1954
Sports/1/E Solenoid for the Electrical Control of the Overdrive March 1954
Sports/2/E Jumping Out of Second Gear April 1954
Sports/3/E Jumping Out of Reverse Gear April 1954
Sports/4/E Accidental Engagement of Reverse Gear April 1954
Sports/5/E Solenoid for Electrical Control of Overdrive October 1954
Sports/6/E Lubricants Approved for Laycock de Normanville Overdrive October 1954
Sports/7/E Overdrive Service Manual December 1954
Sports/1/F Rear Hub – Pressed Steel and Knock-On Type Wire Wheels May 1954
Sports/2/F Rear Axle Crown Wheel Attachment June 1954
Sports/3/F Fitting and Assembly of Rear Hubs August 1954
Sports/4/F Rear Hub Bearing Failure November 1954
Sports/5/F Rear Axle Crown Wheel Attachment Bolts December 1954
Sports/1/G Front Hubs for Pressed Steel Type Wheels May 1954
Sports/2/G Steering Column Bracing June 1954
Sports/3/G Fitting of OIl Retaining Felts to Front Hubs July 1954
Sports/4/G Front Suspension – Trunnion for Vertical Link and Lower Wishbones August 1954
Sports/1/J Skid Plate for Rally Work July 1954
Sports/2/J Rear Shock Absorber Brackets November 1954
Sports/1/L Road Wheel Balance April 1954
Sports/2/L Road Wheel Attachment Nuts May 1954
Sports/1/M Suppression of Radio and Television Interference January 1954
Sports/2/M Flashing Signal Lights February 1954
Sports/3/M Windscreen Wiper Installation June 1954
Sports/4/M Rev. Counter Cable Fouling Overdrive Relay December 1954
Sports/2/N Water Leakage Through the Stitching On Hood, Sidescreens and Tonneau Cover October 1954
Sports/3/N Battery Box Drain December 1954
Sports/1/P Adjustments and Maintenance of S.U. Carburettors, Type H.4. August 1954
Sports/1/Q Rear Hub Extractor May 1954
Sports/2/Q Specialised Tools November 1954
Sports/1/R Brake Backing Plate Attachment Bolts April 1954
Sports/2/R Attachment of Brake Pipes and Hoses July 1954
Sports/3/R Front and Rear Brake Linings September 1954
Sports/1/S Exhaust Silencer May 1954
Vanguard/3/B Engine Ventilation – Series II Design August 1954
Vanguard/3/E Solenoid for Electrical Control of Overdrive October 1954
Vanguard/4/E Lubricants Approved for Laycock de Normanville Overdrive October 1954
Eight/19/N Type of Paint to be Used for Re-Finishing and Re-Touching December 1955
Eight/10/R Fitting of Front Brake Flexible Hoses August 1955
Sports/7/B Use of Sealing Compound on Filter Bracket at Cylinder Block Joint June 1955
Sports/8/B Rocker Cover Gasket June 1955
Sports/9/B Rocker Shaft Pedestal Studs June 1955
Sports/10/B Oil Pressure Knock August 1955
Sports/11/B Reconditioning of Camshaft Bearing Housing September 1955
Sports/12/B Engine Oil Pressure September 1955
Sports/13/B Cylinder Head Nuts December 1955
Sports/14/B Sparking Plugs for Use in Countries Employing Low Octane Fuels December 1954
Sports/15/B Cylinder LIner Gasket, Part No. 108024 December 1955
Sports/8/E Gearbox Rubber Grommet February 1955
Sports/9/E Change Speed Lever Vibration June 1955
Sports/10/E Incorporation of Overdrive Top,” Third” and Second” Gears February 1955
Sports/6/F Oil Leakage to Rear Hubs March 1955
Sports/7/F Rear Axle Shaft Nuts September 1955
Sports/8/F Rear Axle Breather September 1955
Sports/9/F Rear Hubs November 1955
Sports/5/G Steering Column Bracing March 1955
Sports/6/G Front Suspension Bottom Inner Fulcrum Bearings December 1955
Sports/1/H Rear Road Spring – Part No. 301017 February 1955
Sports/3/J Reinforced Jacking System March 1955
Sports/3/L Maintenance of Wire Wheels January 1955
Sports/4/L Fitting of Dunlop Covers with India Tubes July 1955
Sports/4/N Front Door Water Sealing January 1955
Sports/5/N Hood Seam Sealing Lacquer January 1955
Sports/6/N Type of Paint to be Used for Re-Finishing and Re-Touching December 1955
Sports/2/P Stone Shield for Petrol Pump February 1955
Sports/4/R Front Brake Linings January 1955
Sports/5/R Brake and Clutch Master Cylinder Leakage March 1955
Sports/6/R 10″ Rear Brake Drums March 1955
Sports/7/R Brake Lining Identification and Incorporation Details March 1955
Sports/8/R Fitting of Front Brake Flexible Hoses August 1955
Vanguard/11/B Cylinder LIner Gasket, Part No. 108024 December 1955
Eight/8/F Rear Axle Lubricants February 1956
Eight/21/N Paint Thinners March 1956
Sports/4/A T.R.III Information February 1956
Sports/16/B Oil Filter Attachment February 1956
Sports/17/B T.R.II and T.R.III Sparking Plug Settings February 1956
Sports/18/B Dynamo Attachment March 1956
Sports/19/B Big End Bearings May 1956
Sports/20/B Engine Oil Filter October 1956
Sports/2?/B Oil Filter Attachment October 1956
Sports/10/F Rear Axle Lubricants February 1956
Sports/2/H Front Shock Absorbers March 1956
Sports/5/M Starter Motor February 1956
Sports/7/N Paint Thinners March 1956
Sports/3/P Accelerator Pedal Maximum Limit Stop for Left Hand Drive Cars February 1956
Sports/4/P T.R.III Carburettor Needles February 1956
Amendment Amendment to Service Information Sheet No. Sports/4/P March 1956
Sports/9/R Front Brakes March 1956
Sports/10/R Disc Brakes – Front October 1956
Sports/2/S Exhaust Pipe Vibration May 1956
VanguardIII/3/B Oil Filter Attachment February 1956
VanguardIII/5/B Dynamo Attachment March 1956
VanguardIII/7/B Oil Filter Attachment October 1956
VanguardIII/2/M Starter Motor February 1956
Eight/9/B Ignition Timing June 1957
Eight/12/B Sparking Plugs September 1957
Eight/17/E Oil Entering the Speedometer Clock May 1957
Eight/21/E Failure of Overdrive UniDirectional Clutch December 1957
Eight/25/N Wax Protective Coating May 1957
Sports/5/A Recommended Lubricants December 1957
Sports/23/B Camshaft Core Plug March 1957
Sports/24/B Ignition Timing June 1957
Sports/25/B Connecting Rod Bearings September 1957
Sports/26/B Sparking Plugs September 1957
Sports/2/D Clutch Driven Plate with Modified Facing Material June 1957
Sports/13/E Oil Entering the Speedometer Clock May 1957
Sports/14/E Failure of Overdrive UniDirectional Clutch December 1957
Sports/11/F Rear Axle Pinion Flange Attachment January 1957
Sports/5/L Hub Adaptors for Wire Wheels January 1957
Sports/8/N Rear Shock Absorber Attachment April 1957
Sports/9/N Wax Protective Coating May 1957
Sports/10/N Fitting of Listing Rods July 1957
Sports/5/P Carburettor Float Support Bolt Grommet – Part No. 503813 June 1957
Sports/11/R Restrictor Valve – Disc Brakes September 1957
Sports/12/R Wheel Rim Finishers – Disc Brakes December 1957
Sports/13/R Binding of Disc Brakes December 1957
Vanguard III/9/B Camshaft Core Plug March 1957
Vanguard III/2/D Clutch Driven Plate with Modified Facing Material June 1957
Vanguard III/2/F Rear Axle Pinion Flange Attachment January 1957
Sports/16/R Servicing of Brake Disc – T.R.3 Only May 1958
Sports/17/E Excessive Brake Pedal Travel – T.R.3 Only October/November 1958
T-63-7 Lucas RB340 Control Box – Spitfire and Sports Six January 25, 1963
T-63-8 Triumph TR-4 Vibration january 25, 1963
T-63-17 Triumph 1200 & Sports Six – Jumping out of Reverse February 15, 1963
T-63-18 Triumph 1200 – Front Suspension Vertical Links February 15, 1963
T-63-20 Spitfire Jacking Points March 8, 1963
T-63-23 Spitfire Water Shields March 20, 1963
T-63-25 Sports Six & Spitfire Front Wheel Bearings March 20, 1963
T-63-31 Paint Formula Triumph Racing Green April 12, 1963
T-63-35 Location of Spare Ignition and Trunk Keys June 7, 1963
T-63-36 TR-4 Transmissions June 7, 1963
T-63-38 B.30 P.S.E.I. Carburetor June 21, 1963
T-63-39 Spitfire Distributor Point Setting June 21, 1963
T-63-40 Sports Six & Spitfire Lighting Switch June 28, 1963
T-63-42 Herald, Sports Six & Spitfire – Brake Squeak June 28, 1963
T-63-44 Triumph 1200 Chassis Frame June 26, 1963
T-63-45 Triumph 1200 and Sports Six Hood Adjustments June 28, 1963
T-63-46 Spitfire Distributor Tuning Data June 28, 1963
T-63-47 Sports Six B.32 P.I.H. Carburetors June 28, 1963
T-63-48 Paint Formulas June 28, 1963
T-63-49 TR-4 Stromberg Carburetors June 28, 1963
T-63-50 Rear Road Spring – Spitfire July 12, 1963
T-63-52 TR-4 Overheating July 19, 1963
T-63-53 Spitfire H.S.2 S.U. Carburetors August 2, 1963
T-63-54 Brake Hoses & Connections – Triumph Herald, Sports Six and Spitfire August 2, 1963
T-63-55 Spitfire Heater Hoses August 22, 1963
T-63-56 Lichfield Green – Revised DuPont Spec August 22, 1963
T-63-57 Spitfire Frictionless Propellor Shafts August 22, 1963
T-63-58 Sports Six Timing Cover Oil Seal August 22, 1963
T-63-59A Triumph Herald, Triumph 1200 and Spitfire – Generator Reinforcing Bracket September 6, 1963
T-63-60 Sports Six Overdrive Solenoids September 6, 1963
T-63-62 Disc Brake Warranty October 4, 1963
T-63-63 Disc Brakes Parts Information October 4, 1963
T-63-64 Clutch Replacements October 23, 1963
T-63-65 Chassis Frames – Herald October 25, 1963
T-63-66 Small Car Models – Differential Drain Plug November 1, 1963
T-63-67 TR-4 Rear Suspension Nobember 1, 1963
T-63-68 Smog Control Component List November 6, 1963
T-63-69 Lichfield Green Paint – Revised Color Match November 22, 1963
T-63-70 Vendor Items Warranty November 22, 1963
T-63-71 Defective Generators November 22, 1963
T-63-72 Herald 1200 & Sports Six Hood Locating Pins and Brackets November 22, 1963
T-63-73 Front Suspension Vertical Link – Herald and Spitfire December 6, 1963
T-63-74 TR-4 Rear Road Springs December 6, 1963
T-64-1 Spitfire Speedometer Cable Run January 3, 1964
T-64-3 Laycock Overdrive January 3, 1964
T-64-4 Disc Brake Warranty Procedure January 10, 1964
T-64-6 Warranty Claims February 7, 1964
T-64-7 Knock from Rear End – 1200 and Spitfire February 7, 1964
T-64-9 Decimal Times on Warranty Claims February 14, 1964
T-64-10 Warranty Claims February 21, 1964
T-64-11 Paint Color Coding March 6, 1964
T-64-12 Increased Allowances and Warranty Claim SwapOut Sets March 20, 1964
T-64-13 Bendix PushButton Radios March 6, 1964
T-64-15 Center Valve Master Cylinder Seals – Small Car Range May 8, 1964
T-64-16 Triumph 1200, Spitfire and Sports Six Valve Springs May 29, 1964
T-64-17 Spitfire Exhaust System June 26, 1964
T-64-18 TR4 Tire Equipment June 26, 1964
T-64-19 Spitfire Hardtop Sealing June 26, 1964
T-64-20 Triumph Spitfire Body Water Leaks July 2, 1964
T-64-21 Maintenance Periods July 10, 1964
T-64-23 Triumph TR4 Wire Wheel Conversion July 17, 1964
T-64-24 Spitfire Rear Road Springs July 17, 1964
T-64-25 Spitfire & 1200 Propellor Shafts July 17, 1964
T-64-26 1200 Herald Clutch Slip July 24, 1964
T-64-27 Correction & Addition to Flat Rate Schedule August 14, 1964
T-64-28 Oil in Speedometer September 4, 1964
T-64-29 TR4 Front Suspension September 4, 1964
T-64-30 Spitfire Distributor Timing September 18, 1964
T-64-31 Brake Warranty September 25, 1964
T-64-32 TR4 Solenoids September 25, 1964
T-64-33 Goodyear Grand Prix Tires September 25, 1964
T-64-34 Time Schedule Amendment October 23, 1964
T-64-35 Triumph-Aire Warranty October 20, 1964
T-64-36 Lucas Sealed Beam Units October 23, 1964
T-64-37 Leaking Heater Radiator Cores December 3, 1964
T-64-38 Triumph Spitfire Temperature Gauge Transmitter November 25, 1964
T-64-39 Convertible Top Stitching Clear Sealer December 3, 1964
T-64-40 Clutch Release Bearings – Spitfire, 1200 and TR4 December 3, 1964
T-64-41 Triumph TR4 Window Winder Regulator December 10, 1964
T-64-42 Triumph TR4, 1200, Spitfire and Sports Six Brake Hose Assemblies December 10, 1964
T-64-43 Stromberg Carburetors December 10, 1964
T-65-1 Triumph Free Service January 1, 1965
T-65-2 Warranty Claim Numbering Sequence January 1, 1965
T-65-3 Convertible Top Warranty Claims January 1, 1965
T-65-4 Color Coding January 14, 1965
T-65-5 Crankcase Breather Service January 14, 1965
T-65-6 30 B.S.E.I. Carburetor – Herald Models January 14, 1965
T-65-7 Speedometer Equipment – All Models January 14, 1965
T-65-8 Gudgeon Pin Fits January 14, 1965
T-65-9 TR-4 Front Suspension Specification Change January 14, 1965
T-65-10 Rear Spring Data March 4, 1965
T-65-12 TR4 Thermostat April 8, 1965
T-65-14 Triumph TR4 Wire Wheel Conversion April 8, 1965
T-65-15 Negative Ground Vehicle Systems – TR4A Neg. Ground April 15, 1965
T-65-16 Closed Circuit Breather Maintenance – All Models April 15, 1965
T-65-17 Triumph TR4A Tire Pressures April 15, 1965
T-65-18 New Tools for I.R.S. TR4A April 15, 1965
T-65-19 TR4A Soft Top Procedure April 15, 1965
T-65-20 TR4A Radios May 6, 1965
T-65-21 Rear Shock Absorbers – TR4A I.R.S. Models May 6, 1965
T-65-22 TR4A Steering May 6, 1965
T-65-23 Main and Big End Bearings – Herald and Spitfire May 6, 1965
T-65-24 Clutch Assemblies – Herald 1200 and Spitfire May 6, 1965
T-65-25 Engine Oil Filler Cap on Triumph TR4A May 13, 1965
T-65-26 Hertz Rent-A-Car May 20, 1965
T-65-27 TR4A Lubrication May 20, 1965
T-65-28 Crankcase Breather Service May 20, 1965
T-65-29 Wheel Conversion TR4A IRS May 20, 1965
T-65-30 Adjusted Warranty Procedure – Shock Absorbers June 9, 1965
T-65-31 Speedometer Warranty Procedure – All Models June 17, 1965
T-65-32 Tire Pressures for Goodyear 165-15 G800 and Dunlop 590-15 C41 Tires June 24, 1965
T-65-36 Traffic Indicator Switches – Herald, Sports Six, Spitfire and TR4 August 26, 1965
T-65-37 I.R.S. Modification – TR4A and Triumph 2000 September 9, 1965
T-65-38 Rear Main Oil Leaks September 9, 1965
T-65-39 Coolant Level – No Loss Systems September 16, 1965
T-65-40 Engine Modification – Spitfire Mark II September 15, 1965
T-65-41 Rear Wheel Alignment – Triumph 2000 and TR4A Models September 30, 1965
T-65-42 I.R.S. Axle Lubricants October 14, 1965
T-65-44 Borg Warner Fluid Level – Triumph 2000 Only October 14, 1965
T-65-45 Crankshaft Thrust Washers – Spitfire & Herald Models October 21, 1965
T-65-47 Crankcase Ventilation Devices December 16, 1965
T-65-48 High Reading Temperature – TR4A December 16, 1965
T-66-2 Triumph 2000 Special Tool January 1, 1966
T-66-3 TR4A Overdrive January 1, 1966
T-66-4 TR4 and TR4A Ground Strap Position January 1, 1966
T-66-5 Triumph 2000 – Windscreen Wiper Motors January 1, 1966
T-66-6 Water Delivery Tube January 1, 1966
T-66-7 Fan Pulley Failure – TR4A Only January 6, 1966
T-66-8a Triumph 2000 Borg Warner Automatic Transmission January 21, 1966
T-66-9 Oil Consumption January 21, 1966
T-66-10 Starter Solenoid – TR4A February 10, 1966
T-66-14 Correction of Bulletin T-65-43 March 3, 1966
T-66-15 I.C.I. Paint March 3, 1966
T-66-16 New Flat Rate Manual March 17, 1966
T-66-17 Wrist Pin & Special Tool – 1200 & Spitfire March 24, 1966
T-66-18 Rack and Pinion Lubrication – All Models March 24, 1966
T-66-19 Warranty Claims March 29, 1966
T-66-20 New Car Storage March 29, 1966
T-66-21 Hub Adaptors – TR Models March 29, 1966
T-66-22 Brake Hoses & Connections – Triumph Herald, Triumph 1200, Sports Six and Spitfire March 29, 1966
T-66-23 Triumph Herald, Triumph 1200 and Spitfire – May 6, 1965
Generator Reinforcing Bracket March 29, 1966
T-66-24 TR4 Rear Road Springs March 29, 1966
T-66-25 Brake Squeal, Triumph 1200 April 7, 1966
T-66-26 Special Safety Check Campaign – Brake Pipe April 27, 1966
T-66-27 Soft Tops – All Models April 27, 1966
T-66-28 Triumph 2000 Instrument Cluster April 28, 1966
T-66-29 Borg Warner Warranty Claims – Triumph 2000 April 28, 1966
T-66-30 Paint Formulas May 19, 1966
T-66-31 Special Safety Check Campaign – Brake Pipe May 18, 1966
T-66-32 Steering Column/Rack Coupling – June 9, 1965 Herald, Spitfire, Sports Six June 9, 1966
T-66-33 Specification Changes – TR4A and Spitfire Mk II June 16, 1966
T-66-35 Wire Wheels July 8, 1966
T-66-36 Inspection of Disc Brake Pads July 9, 1966
T-66-37 TR4A Hood Release July 19, 1966
T-66-39 Rear Oil Seal & Special Tool – All Models Except TR4A July 19, 1966
T-66-40 Testing and Diagnosing Faults on the BiMetal Fuel and Temperature Circuits August 11, 1966
T-66-41 Soft Top Tonneau Cover Snaps August 11,, 1966
T-66-42 rear Brake Cylinders – TR Range August 11, 1966
T-66-43 Water Hoses August 25, 1966
T-66-45 Claims on Gear Box and Rear Axle September 22, 1966
T-66-48 Rear Road Spring – TR4A I.R.S. Only October 21, 1966
T-66-49 Wire Wheel Attachment October 21, 1966
T-66-50 Gear Lever Rattle – Triumph 2000 October 21, 1966
T-66-51 Oil Leakage from BorgWarner Transmission - Triumph 2000 Only October 21, 1966
T-66-53 Servicing TR4A IRS & 2000 Differential December 15, 1966
T-66-54 Thermostats December 15, 1966
T-66-55 Clutch Adjustment, TR4A Only December 15, 1966
T-67-1 Spitfire Speedometer Cable Run January 12, 1967
T-67-2 Laycock Overdrive January 12, 1967
T-67-3 Claims on Gearbox and Rear Axle January 19, 1967
T-67-4 Disc Brake Warranty Procedure January 19, 1967
T-67-5 GT6 Battery Terminal January 26, 1967
T-67-6 Warranty Claims January 26, 1967
T-67-7 Paint Color Coding February 2, 1967
T-67-8 Spitfire Hardtop Sealing February 2, 1967
T-67-9 Spitfire Rear Road Springs February 9, 1967
T-67-10 Triumph TR4, 1200, Spitfire and Sports Six Brake Hose Assemblies February 9. 1967
T-67-11 Piston Grading February 16, 1967
T-67-12 Generators and Control Boxes February 16, 1967
T-67-13 Gearbox Noise – GT6 February 16, 1967
T-67-14 Gear Lever Rattle – TR4 and TR4A Only February 23, 1967
T-67-15 Calipers and Brake Pads – Triumph 2000 February 23, 1967
T-67-17 Tire Pressure Recommendations April 6, 1967
[Note: This is the last bulletin in the photocopied package available until October, 1974.]
74-H-1 AntiFreeze October, 1974
75-A-1 Pistons January, 1975
75-D-2 Gearbox Modifications February, 1975
76-B-10C Servicing of Electronic Modules for In-Built Electronic Distributors January, 1977
77-A-1 Crankshaft Spigot Bush Squeal January, 1977
77-A-3 Cylinder Head Gasket January, 1977
77-D-1 Revised Gear Set January, 1977
77-D-2 Reverse Gear Ratio January, 1977
77-A-6 Exhaust Down Pipe and Flange Gasket Failures June, 1977
A444 Main Light Switch Safety Recall Campaign Letter June 6, 1978
[Ed. Note: These are the only bulletins in the photocopied package available from mid 1967 through the end of Triumph exports to the United States in 1981. It is not known if other bulletins are extant for this period, or for Triumph produced for domestic sale, such as the Acclaim, after 1981.]
Posted in Articles/Documents
Leave a Reply
| « Jun |
|
Sep » |
| S | M | T | W | T | F | S |
|---|---|---|---|---|---|---|
| 1 | 2 | 3 | ||||
| 4 | 5 | 6 | 7 | 8 | 9 | 10 |
| 11 | 12 | 13 | 14 | 15 | 16 | 17 |
| 18 | 19 | 20 | 21 | 22 | 23 | 24 |
| 25 | 26 | 27 | 28 | 29 | 30 | 31 |
| S | M | T | W | T | F | S |
|---|---|---|---|---|---|---|
| 1 | 2 | 3 | 4 | 5 | 6 | 7 |
| 8 | 9 | 10 | 11 | 12 | 13 | 14 |
| 15 | 16 | 17 | 18 | 19 | 20 | 21 |
| 22 | 23 | 24 | 25 | 26 | 27 | 28 |
| 29 | 30 | 31 | EC | |||